united chemi-con, inc. 9801 w. higgins road, rosemont, il 60018 tel 847-696-2000 fax 847-696-9278 www.chemi-con.com 16 2 smebp miniature - 85 c sme bp series the smebp series capacitors are the bi-polar versions of the sme series, and are designed for use in circuits in which polarity is sometimes reversed or unknown. please note that these capacitors cannot withstand an ac application in which the maximum ripple current is exceeded. the smebp series capacitors were developed to withstand hcfc cleaning agents for five minutes by ultrasonic, vapor or immersion. this solvent proof design allows all circuit board components to be cleaned together, at the same time, without resorting to more expensive epoxy end-sealed capacitors. refer to the mini-glossary for recommended cleaning conditions. miniature bi-polar solvent proof 85 c maximum temperature radial lead terminals. capacitance range: 0.47 to 6,800 f. voltage range: 6.3 to 100vdc. operating temperature range: 40 cto 85 c. leakage current: 0.06cv or 10?, whichever is greater, after 1 minute or 0.03cv or 3 a, whichever is greater, after 5 minutes at 20 c. standard capacitance tolerance: 20% nominal case size (d l): 5 11mm to 18 35.5mm. rated lifetime: 2,000 hours at 85 c. summary of specifications actual size
united chemi-con, inc. 9801 w. higgins road, rosemont, il 60018 tel 847-696-2000 fax 847-696-9278 www.chemi-con.com 16 3 smebp series smebp miniature - 85 c smebp specifications item operating temperature range 40 to 85 c rated voltage range 6.3 to 100vdc capacitance range 0.47 to 6,800 f capacitance tolerance 20% ( m ) at 20 c, 120hz leakage current i 0.06cv or 10 a, whichever is greater, after 1 minute at 20 c. i 0.03cv or 3 a, whichever is greater, after 5 minutes at 20 c. where i = leakage current ( a ), c = nominal capacitance ( f ) and v = rated voltage ( v ) characteristics low temperature characteristics at 120hz, impedance ( z ) ratio between the 25 c or 40 c value and 20 c value shall not exceed the values given below. ripple current multipliers refer to section 4 of the mini-glossary for explanation of ripple current multipliers. ambient temperature ( c) 70 c 1.30 85 c 1.00 frequency (hz ) shelf life others the following specifications shall be satisfied when the capacitors are restored to 20 c after exposing them for 1,000 hours at 85 c without voltage applied. the rated voltage shall be applied to the capacitors for a minimum of 30 minutes, at least 24 hours and not more than 48 hours before the measurements. capacitance change: 25% of initial measured value for 16v : 20% of initial measured value for 25v tan (df) : 150% of initial specified value leakage current : initial specified value satisfies characteristic w of jis c5141 load life the following specifications shall be satisfied when the capacitors are restored to 20 c after subjecting them to the dc rated voltage for 2,000 hours at 85 c. polarization shall be reversed every 250 hours. the sum of dc voltage and peak ac voltage must not exceed the full rated voltage of the capacitors. capacitance change: 25% of initial measured value for 16v : 20% of initial measured value for 25v tan (df) : 150% of initial specified value leakage current : initial specified value dissipation factor ( tan )at 20 c, 120hz when nominal capacitance exceeds 1,000 f, add 0.02 to the values above for each 1,000 f increase. rated voltage ( v ) tan (df) 6.3 -10 0.24 16 - 25 0.20 35 0.16 50 0.14 63 -80 0.12 100 0.10 rated voltage ( v ) z( 25 c) /z( 20 c) z( 40 c) /z( 20 c) 6.3 4 10 10 3 8 16 2 6 25 2 4 35 2 3 50 2 3 63 -100 2 3 capacitance ( f) 3.3 f 4.7- 33 f 47-1000 f 2200 f 50hz 0.65 0.75 0.80 0.85 120hz 1.00 1.00 1.00 1.00 300hz 1.35 1.25 1.15 1.03 1khz 1.75 1.50 1.30 1.05 10khz 2.30 1.75 1.40 1.08 100khz 2.50 1.80 1.50 1.08
smebp series united chemi-con, inc. 9801 w. higgins road, rosemont, il 60018 tel 847-696-2000 fax 847-696-9278 www.chemi-con.com 16 4 smebp miniature - 85 c rated voltage (wvdc) capacitance ( f) catalog part number nominal case size* d l ( mm ) maximum ripple current ( ma rms) at 85 c, 120hz maximum esr ( ? ) at 20 c, 120hz standard voltage ratings - vb/radial lead 330 smebp6.3vb331m8x11ll 8 11.5 1.205 265 470 smebp6.3vb471m10x12ll 10 12.5 0.846 370 1,000 smebp6.3vb102m10x20ll 10 20 0.398 650 2,200 smebp6.3vb222m12x25ll 12.5 25 0.196 1,160 3,300 smebp6.3vb332m16x25ll 16 25 0.141 1,570 4,700 smebp6.3vb472m16x31ll 16 31.5 0.106 2,020 6,800 smebp6.3vb682m18x35ll 18 35.5 0.083 2,600 6.3 volts 8 volts surge 47 smebp10vb47rm5x11ll 5 11 8.464 76 100 smebp10vb101m6x11ll 6.3 11 3.978 125 220 smebp10vb221m8x11ll 8 11.5 1.808 215 330 smebp10vb331m10x16ll 10 16 1.205 345 10 volts 13 volts surge * the case sizes in table are with no sleeve, refer to diagram for case sizes with sleeve. vb/radial lead unit: mm diagram of dimensions lead length: ll is standard. case code: see case sizes in tables. capacitance tolerance: m = 20% capacitance value: expressed in microfarads. the first two digits are significant figures, and the third digit indicates the number of zeros for capacitance of 100 f or more. r indicates the decimal point for capacitance less than 100 f (e.g. r22 = .22 f; 2r2 = 2.2 f; 22r = 22 f; 221 = 220 f; 222 = 2,200 f; 223 = 22,000 f). lead configuration: vb = radial lead terminals. dc rated voltage: expressed in volts (e.g. 35 = 35wvdc). series name: indicates basic capacitor design. part numbering system for smebp series when ordering, always specify complete catalog number for smebp series. smebp 35 vb 22r m 6x11 ll d 5 6.3 8 10, 12.5 16, 18 d ' max. d 0.5 d 0.5 d 0.5 d 0.5 d 0.5 l ' max. l 1.5 l 1.5 l 1.5 l 1.5 l 1.5 d 0.5 0.5 0.6 0.6 0.8 f 0.5 2.0 2.5 3.5 5.0 7.5 f f f f 15 min. pvc sleeve d ' d vent (except 5) l ' l d 5 ~ 8 12.5 ~ 18 10 4 min. gas escape end seal for all case diameters. for optional lead configurations and tape and ammo packaging, refer to the beginning of the miniature section.
united chemi-con, inc. 9801 w. higgins road, rosemont, il 60018 tel 847-696-2000 fax 847-696-9278 www.chemi-con.com 16 5 smebp series smebp miniature - 85 c rated voltage (wvdc) capacitance ( f) catalog part number nominal case size* d l ( mm ) maximum ripple current ( ma rms) at 85 c, 120hz maximum esr ( ? ) at 20 c, 120hz standard voltage ratings - vb/radial lead 470 smebp10vb471m10x16ll 10 16 0.846 410 1,000 smebp10vb102m12x20ll 12.5 20 0.398 720 2,200 smebp10vb222m16x25ll 16 25 0.196 1,280 3,300 smebp10vb332m16x31ll 16 31.5 0.141 1,690 4,700 smebp10vb472m18x35ll 18 35.5 0.106 2,160 10 volts 13 volts surge 22 smebp16vb22rm5x11ll 5 11 15.068 57 33 smebp16vb33rm5x11ll 5 11 10.045 70 220 smebp16vb221m10x12ll 10 12.5 1.507 275 330 smebp16vb331m10x16ll 10 16 1.005 375 470 smebp16vb471m10x20ll 10 20 0.705 485 1,000 smebp16vb102m12x25ll 12.5 25 0.332 855 2,200 smebp16vb222m16x31ll 16 31.5 0.166 1,510 3,300 smebp16vb332m18x35ll 18 35.5 0.121 1,980 16 volts 20 volts surge 33 smebp25vb33rm6x11ll 6.3 11 10.045 80 47 smebp25vb47rm6x11ll 6.3 11 7.053 95 100 smebp25vb101m8x11ll 8 11.5 3.315 160 220 smebp25vb221m10x16ll 10 16 1.507 305 330 smebp25vb331m12x20ll 12.5 20 1.005 450 470 smebp25vb471m12x20ll 12.5 20 0.705 540 1,000 smebp25vb102m16x25ll 16 25 0.332 950 2,200 smebp25vb222m18x35ll 18 35.5 0.166 1,620 25 volts 32 volts surge 10 smebp35vb10rm5x11ll 5 11 26.52 43 22 smebp35vb22rm6x11ll 6.3 11 12.055 73 47 smebp35vb47rm8x11ll 8 11.5 5.643 120 100 smebp35vb101m10x16ll 10 16 2.652 230 220 smebp35vb221m12x20ll 12.5 20 1.205 410 330 smebp35vb331m12x20ll 12.5 20 0.804 505 470 smebp35vb471m12x25ll 12.5 25 0.564 655 1,000 smebp35vb102m16x31ll 16 31.5 0.265 1,140 35 volts 44 volts surge 0.47 smebp50vbr47m5x11ll 5 11 493.723 11 1.0 smebp50vb1r0m5x11ll 5 11 232.05 17 2.2 smebp50vb2r2m5x11ll 5 11 105.477 25 3.3 smebp50vb3r3m5x11ll 5 11 70.318 27 4.7 smebp50vb4r7m5x11ll 5 11 49.372 34 10 smebp50vb10rm6x11ll 6.3 11 23.205 52 22 smebp50vb22rm8x11ll 8 11.5 10.548 89 33 smebp50vb33rm8x11ll 8 11.5 7.032 105 47 smebp50vb47rm10x12ll 10 12.5 4.937 150 100 smebp50vb101m10x20ll 10 20 2.321 265 220 smebp50vb221m12x25ll 12.5 25 1.055 480 330 smebp50vb331m16x25ll 16 25 0.703 650 470 smebp50vb471m16x31ll 16 31.5 0.494 835 50 volts 63 volts surge * the case sizes in table are with no sleeve, refer to diagram for case sizes with sleeve. 3.3 smebp63vb3r3m5x11ll 5 11 60.273 28 4.7 smebp63vb4r7m6x11ll 6.3 11 42.319 34 10 smebp63vb10rm6x11ll 6.3 11 19.89 57 22 smebp63vb22rm8x11ll 8 11.5 9.041 96 33 smebp63vb33rm10x12ll 10 12.5 6.027 135 47 smebp63vb47rm10x16ll 10 16 4.232 180 100 smebp63vb101m12x20ll 12.5 20 1.989 320 220 smebp63vb221m16x25ll 16 25 0.904 575 330 smebp63vb331m16x31ll 16 31.5 0.603 755 470 smebp63vb471m18x35ll 18 35.5 0.423 965 63 volts 79 volts surge
smebp series united chemi-con, inc. 9801 w. higgins road, rosemont, il 60018 tel 847-696-2000 fax 847-696-9278 www.chemi-con.com 16 6 smebp miniature - 85 c rated voltage (wvdc) capacitance ( f) catalog part number nominal case size* d l ( mm ) maximum ripple current ( ma rms) at 85 c, 120hz maximum esr ( ? ) at 20 c, 120hz standard voltage ratings - vb/radial lead 0.47 smebp100vbr47m5x11ll 5 11 352.66 14 1.0 smebp100vb1r0m5x11ll 5 11 165.75 21 2.2 smebp100vb2r2m6x11ll 6.3 11 75.341 34 3.3 smebp100vb3r3m6x11ll 6.3 11 50.227 39 4.7 smebp100vb4r7m6x11ll 6.3 11 35.266 47 10 smebp100vb10rm8x11ll 8 11.5 16.575 71 22 smebp100vb22rm10x16ll 10 16 7.534 135 33 smebp100vb33rm12x20ll 12.5 20 5.023 220 47 smebp100vb47rm12x20ll 12.5 20 3.527 240 100 smebp100vb101m16x25ll 16 25 1.658 425 220 smebp100vb221m18x35ll 18 35.5 0.753 720 100 volts 125 volts surge * the case sizes in table are with no sleeve, refer to diagram for case sizes with sleeve. 2.2 smebp80vb2r2m5x11ll 5 11 90.409 29 22 smebp80vb22rm10x16ll 10 16 9.041 125 33 smebp80vb33rm10x16ll 10 16 6.027 150 47 smebp80vb47rm10x20ll 10 20 4.232 195 100 smebp80vb101m12x25ll 12.5 25 1.989 350 220 smebp80vb221m16x31ll 16 31.5 0.904 615 330 smebp80vb331m18x35ll 18 35.5 0.603 755 80 volts 100 volts surge
|
